Drivers were highly skilled enginemen. Taking a train from Beech Forest to down to Gellibrand required the train to be controlled at 10 mph (16 km) without running out of air. When a brake application was made the brakes on the locomotive were applied harder than the train brakes. The brakes locked up and the engine would just slide along. Drivers used a retention valve on the loco, then released the loco brakes so as not to wear out the brake shoes. So the train pulled into Gellibrand ready to pull out again after refilling the loco with water.At Gellibrand, a Down goods train is about to depart the station on 14 December 1955. The train consists of the locomotive G42, a louvre van NO, two NQ wagons and a guard's or brake van NC. B/W.gellibrand; colac; beech forest; railway;

Drawing of the air brake system on a Melbourne tram using a self lapping brake and relay valve - the charging and release positions. 89.1 - shows the relay valve in the exhaust position 89.2 - shows the valve in the applied position. Has been drawn in ink on a piece of paper, and the coloured red or green as necessary to show the various positions and state of the valves, reservoir, brake cylinder and pipes.trams, tramways, mmtb, braking, brake valves

Drawing details brake rigging and dimensions for a Brill 22E truck. Dated 4/8/1947, prepared by the SEC Geelong branch, signed by H N Hornabrook 6/8/47 showing the layout and loads on each part of the brake system, drawing No. T1647. See item 9025 and 9857 for other versions.Yields information about the brake rigging for Brill 22E trams and demonstrates the activities of the SEC Geelong office.Drawing - blueprint, titled "Brake rigging dropped centre double bogie tram Brill maximum traction truck 22E, Trams Nos. 31,""D1775" in ink on top sheet right hand corner.brill 22e, drawings, brake rigging, geelong

Manuscript - two typed quarto sheets - titled "Ferodoisation" written by "Dick Kerr", looking at the use of Ferodo brake shoes in Melbourne. Looks at costs, service, noise, braking, disadvantages of noise, smell, dust and braking effort. See also Reg Item 3054 - "Electric Traction - May 1969", that has an article by "Richard Kerr" - most likely the same author and the collector - Bob Prentice. With the manuscript are two photographs of the brake blocks and drawing of a wheel marked Fig 1 and Fig 2 - these are not referenced in the article.trams, tramways, mmtb, brakes, ferodo brakes shoes, braking, tramcars

NC Van The NC guard's vans were originally classed NDD. In the 1910 reclassification they were classified NC. Apart from the windows and height they were externally the same as the NBC vans. Inside there were benches along both side walls. One end was equipped with a small guard's compartment. This had two corner seats, two desks with ticket selling windows and a letter rack. A novel feature was a folding dog cage under one of the benches. Six NC Brake Van / Guards Vans were built by Victorian Railways 1 NC was built in 1909 as NDD and reclassed 1NC in 1910. 2 NC was built and placed into service Nov 1912 3 NC , 4 NC and 5 NC were built and placed into service June / July 1914 6 NC was Built and placed into service in 1919 1 NC, 4 NC and 6 NC were all scrapped by Victorian Railways between 1954 and 1957 Van 5NC - Brake Van (4 ton capacity) In Active Service - Belgrave Station Yard VR Service History: 5 NC *NC 5.VA - 31/ 7/1914 NWS Built new - / 6/1926 - Modified AC Malco 16/11/1932 NWS Into Workshops - 9/12/1932 NWS Out of Workshops (24 days) 23/10/1935 NWS Into Workshops - 19/11/1935 NWS Out of Workshops (28 days) 10/ 8/1939 NWS Into Workshops - 8/ 9/1939 NWS Out of Workshops (30 days) 2/ 6/1944 NWS Into Workshops - 25/ 8/1944 NWS Out of Workshops (85 days) 21/ 4/1949 NWS Into Workshops - 14/10/1949 NWS Out of Workshops (178 days) Dec 2016 - Puffing Billy Register of Rolling Stock NC 5 Brake Van (4 ton capacity) - In traffic Historic - Victorian Railways - Narrow Gauge Rolling Stock - NC Brake Van Victorian Heritage Register (VHR) Number H2187 The Puffing Billy Rolling Stock CollectionBrake Van (4 ton capacity) made of Timber and wrought iron5NCpuffing billy, 5nc, 2'6" gauge, victorian railways, 5nc brake van

Issued to employees of the VR St Kilda to Brighton electric street railway, superseding previous copies. The line closed in 1956. Note the spelling of the word "employe" with an accent over the e - an acceptable practice in Victoria at the time - a US based spelling. Book scanned into multiple parts. See Reg Item 3508 for a "Supplement to the Book of Instructions re the working of the St Kilda and Brighton Electric Street Railway, dated 1/1/1915", item 7518 for a June 1907 version, and 7580 for instructions issued in 1911.Demonstrates a Victorian Railway Rule book for electric tramways or Street Railways.Rule Book - 156 pages, five sewn sections within a green coloured Rexene heavy card with glued endpapers with the title "Victorian Railways Instructions re Working of the St Kilda and Brighton Electric Street Railway" and "1927" in gold block. Dated 1 June 1926. Has a table of contents and index - gives definitions - "trams" vs "street railways", general instructions, hand signs, working of cars, working of traffic over single and double line, staff and ticket systems, air brakes, permanent way, overhead, fares, appeals of employees against penalty and electric shock.Copy 3 has stamp of the "Westinghouse Brake Inspector" and "Lloyd Rogers" in ink on the inside front cover. On page 94 and 95 has notes in pencil about the air braking system - may have been for a following issue.trams, tramways, victorian railways, vr, st kilda brighton, rules, employees, safeworking

35mm Kodak white cardboard colour slide by Keith Kings of per way works car No. 15 being used to transport brake shoes (blocks) around the depot. Being loaded at Preston Workshops. 16/4/1968Keith Kings stamp and number "21-36", with details of exposure. in ink "MMTB No. 15 (ex Q 198) being used to transport brake shoes around the depot. Being loaded at Preston Workshops.trams, tramways, work trams, brake blocks, tram 15

Set of two documents: 1 - Braking chart for a retardation or deceleration of 4 ft/sec/sec - for miles per hour and distance in feet. 2 - calculations for above.Yields information about braking distances for various speeds.Set of two documents - on quarto graph paper and hand written foolscap sheet.trams, tramways, brakes, braking

Has a table of contents, outlines the rules of operating brake equipment fitted to tramcars, the SM3, SX2 brake valve, locomotive straight air, installation piping, wiring, maintenance - piston travel, lubrication, car tests, hints to Motormen and Conductors and General Hints. Schedule for SM-1 and featherweight equipment. Includes instructions on compressors, air intakes, valves, cylinders and governors.Provides instructions about Westinghouse air brake equipment used on tramcars around the world.Instruction - 48 pages + light brown card cover centre stapled with cloth binding on outer edge + 13 fold out drawings inside the rear cover, titled "Westinghouse - T5001-1 Straight-Air Brake Equipment". Dated March 1923. On first page a signature in ink - "W. Armstrong"?brakes, electrical engineering, •electrical equipment, •westinghouse, •air compressors, •instructions, •maintenance

NC Van The NC guard's vans were originally classed NDD. In the 1910 reclassification they were classified NC. Apart from the windows and height they were externally the same as the NBC vans. Inside there were benches along both side walls. One end was equipped with a small guard's compartment. This had two corner seats, two desks with ticket selling windows and a letter rack. A novel feature was a folding dog cage under one of the benches. Six NC Brake Van / Guards Vans were built by Victorian Railways 1 NC was built in 1909 as NDD and reclassed 1NC in 1910. 2 NC was built and placed into service Nov 1912 3 NC , 4 NC and 5 NC were built and placed into service June / July 1914 6 NC was Built and placed into service in 1919 1 NC, 4 NC and 6 NC were all scrapped by Victorian Railways between 1954 and 1957 2NC - Brake Van (4 ton capacity) VR Service History 26/11/1912 NWS Built new 2 NC *NC 2.VA - 26/11/1912 NWS Built new - circa 1926 - Modified AC Malco BO 6/ 7/1932 NWS Into Workshops - 5/ 8/1932 NWS Out of Workshops (31 days) 2/10/1937 NWS Into Workshops - 3/12/1937 NWS Out of Workshops (63 days) 25/ 1/1945 NWS Into Workshops - 23/ 2/1945 NWS Out of Workshops (30 days) Dec 2016 - Puffing Billy Rollling Stock register Puffing Billy Service History or Notes 21 Oct 1995 - Loco 7A and 2 NC collides with trolleys NK 3, Jenny, & NG 1 on the SELBY side of the MONBULK CREEK trestle bridge. Historic - Victorian Railways - Narrow Gauge Rolling Stock - NC Brake VanBrake Van (4 ton capacity) made of Timber and wrought iron2NCpuffing billy, 2nc, 2'6" gauge, victorian railways, 2 nc brake van

Significant in being an assembled set of instructions that were used by tram crews for reference by management.Set of four SEC staff instructions stapled together for reference by managers. Stapled along the top edge with staples. Comprise: “Forest City” Signals – 5 pages – with handwritten notes on page 5, regarding “Shortening of signal section” dated 20 Jan 1965. – see Reg Item 3456 Tramcar Emergency Braking – 25/1/1965 – 2 pages – Reg Item 3457 Question and Answer paper – Brake Equipment Descriptions, etc. – 4 pages – Reg items 272, 3457, Special Order to Motorman (49/1) – 2 pages – 25/1/1965 – Reg item 3459 and 5371 for an undated issue. See the various Registered items for more details and 5370 for an undated version of the Tramcar Emergency Braking. Page 5 of the first document has hand written notes about “Shortening of signal section” Top sheet has a number of initials of people who have read/sighted the document - dated 8/11/1965 and 11/12/1965.trams, tramways, sec, instructions, braking, emergency, forest city signals

The Westinghouse Brake A Refernce Book Publisher: The Westinghouse Brake Company Limited Date: 1892flagstaff hill, warrnambool, shipwrecked-coast, flagstaff-hill, flagstaff-hill-maritime-museum, maritime-museum, shipwreck-coast, flagstaff-hill-maritime-village, the westinghouse brake, book, great ocean road

Drays were used to transport heavy materials such as farm products, building supplies, food. They were pulled by horses or bullocks. Drays were important for transportation in the Kiewa Valley.Made of timber and steel. The piece of wood contacts the axle hub to brake the dray. Part of a brake for a dray. It is missing the actuator that is needed for tightening the band to operate as a brake.drays, horses, bullocks

Two reports on PCC type tramcar No. 980, contained within one bound document. Pages 1-9, Drum Brake Characteristics - April 1951 (B15/1/22) and pages 10 - 16, Dynamic Brake Service Test - May 1951 (B15/1/23). Documents stapled on left hand side and bound with adhesive tape. First report looks at the braking of the tram and problems with getting smooth stops, issues and what changes could be made, signed by the Testing Engineer D.H. Eakins 4/7/51. Second report - further testing following the first report, gives methodology, analysis and results - no significant improvement over those previously obtained.trams, tramways, preston workshops, reports, tramcars, pcc, braking, tram 980, tram 959

Charts 2, 3, 4 and 6 or drawings showing automatic brake operations for possibly Ballarat tram 26 which was trialled in Ballarat during 1948 See item 9894 for instructions and item 9891 for a memo regarding operations. Shows the various stages of operations. Charts 1 and 5 missing.Demonstrates SECV document and chart of operations about the trialing of automatic braking systems on tram 26.Set of four foolscap sheets - dye line prints, marked up in red ink.tramways, ballarat, brakes, tramcar brakes, braking, tram 26

2287.1 - Four page technical pamphlet, titled "Combined Guard's Van Valve and Gauge for Vacuum Brakes", published by Westinghouse Brake and Saxby Signal Co. Ltd. November 1926. Manual No. D.P. 8. 2287.2 - Eight page technical pamphlet, titled "Brake Control Valve for Automatic Vacuum Brake", published by Westinghouse Brake and Saxby Signal Co. Ltd. January 1928, Manual No. D.P. 15. Saddle Stapled. 2287.3 - Twelve page technical pamphlet, titled "Vacuum Brake Apparatus", published by Westinghouse Brake and Saxby Signal Co. May 1924, Manual No. D.P. 3. Saddle Stapled. 2287.4 - Eight page technical pamphlet, titled "Prestal Vacuum Brake Cylinders Combined and Separate Types", published by Westinghouse Brake and Saxby Signal Co. Ltd. January 1928, Manual No. D.P. 14. Saddle Stapled. Two copies held.Each have "Colin Rutledge" stamped on top of page 1.trams, tramways, westinghouse, railway brakes, vacuum brakes, equipment

Yields information about the instructions about tram operations, safety instructions and leaving trams.Two foolscap duplicated sheets titled "Special Order to Motormen (49/1)" giving instructions regarding 1) Responsibility (for trams), 2) Relief on the road, 3) Controller key, 4) Air brake handle, 5) leaving tram unattended with definition, general precautions, special precautions - such as parking the tram at Lydiard St North, parking trams at City Loop and 6) an explanation on the braking system at either end of the tram. Undated. Printed from wax stencil and stapled along the top edge. Signed by F. K. White Manager. See Reg Item 261 for 9-1961 issue and Reg item 3459 for a Jan. 1961 issue. trams, tramways, braking, instructions, sec, emergency, driver training

Forty One page book with dark red cover titled "Compressed Air Brakes for Tramways", published by Westinghouse Brake and Saxby Signal Co. May 1929. Cover - cloth texture laminated paper cover, dark red on outside, with embossed title and publishing details and Westinghouse logo embossed on rear cover. Forty printed pages sewn at three points into cover with page 41, tipped onto right hand edge of page 40, with a blind perforated strip to enable the sheet to be used as an Enquiry form to obtain a price regarding tram brake equipment. Covers compressed air brake systems in general for tramways, including layout drawings, straight air brake, braking ratio, brake cylinder sizing, reservoirs, air compressor type E13, DH16, E13, Governors ES16, Brake Valve No. 13, 9, brake cylinder, sand ejectors, reservoirs drain cocks, with an appendix describing the automatic brake system for use with trailers. Manual No. DP12."Colin Rutledge" stamped on top of page 1.trams, tramways, westinghouse, tramcar brakes, compressors, governors, equipment

2285.1 - 12 page technical pamphlet (2 sheets of paper - pages 5 -10 formed as a concertina folded centre sheet) titled "Interlocked electo-pneumatic brake", published by Westinghouse Brake Company of Australasia Limited, December 1926. Manual D.P. 9. Stapled with two steel staples along fold. Describes in detail the electro-pneumatic brake system as used on Sydney Suburban trains, complete with diagrams, brake valve operation, magnet valve and isolating cock switch. 2285.2 - Six page technical pamphlet, titled "The Westinghouse Brake with electro-pneumatic control", published by Westinghouse Brake and Saxby Signal Co. 1915. Pages 3 and 4 have been tipped in the cover sheet. Describes standard brake equipment for use with electric trains and electro pneumatic control over the brakes. Gives details of house the brake valve (No. 18 EP) operates. Scanned to the COTMA Website 4-10-2015."Colin Rutledge" stamped on top of page 1.trams, tramways, westinghouse, electric trains, electro - pneumatic brakes, sydney suburban trains

Tramcar Brake Shoe in worn and broken conditionballarat, tramcar, brake shoe

Demonstrates aspects of the Ballarat Tramways system of training Motorman or drivers in the 1960's and the information there were given on driving trams. Shows the training methods of the time. 3486.1 - also details "Dead Man Brakes"Thirty Three page - carbon copy - within stapled light card covers - Ballarat Motorman (Driver) Training Manual or Guide - not a formal title. On front cover is large letter "G" and words "To be returned to the inspectors office after completion of Training as Motorman" First four pages has index and covers: (A) Tramcar Equipment - electrical - items or clauses 1 to 28 (B) Location of Faults - items 29 - 41 (C) Tramcar Braking - items 42 to 59 (D) Failure of the Mechanical Brakes - items 60 to 67 (E) Tramcar Emergency Braking (Accident Prevention) - items 68 - 72 (F) Automatic Electric Signals - items 73 - 82 - gives locations of signals. (G) General Instructions - items 83 to 98. See condition notes - not in the best condition - needs careful handling. 3486.4 - ditto - similar to above, but 34 pages through to instruction 104. Added section (F) after (E) - "Automatic Braking - clauses 72 - 79, possibly an earlier version of above when trams were fitted with dead man controls. Held within a cardboard folder with a metal binder. Cover has been covered with brown paper and adhesive tape, but only remains on the inside of the cover. Item added 3/10/2007. See Reg Item 8110i for a Bendigo, c1940 version.See above 3486.1 - has "Hall G - M.Cond" on front cover. Another name has been rubbed out.trams, tramways, driver training, sec, signals, braking, equipment, emergency, dead man controls

.1 - single A4 sheet - titled "W class Safety Alert - Fail Safe Park Brake", dated 24/3/2006, detailing procedures for the use of the parking braking system fitted to W class tramcars. Includes a photograph of the button. .2 - Instruction - from Staff Induction Manual, detailing terminus procedures for Malvern Depot; University terminus, Malvern Burke Road, Glen Iris, Camberwell and Kew terminus for Z and Combino trams .3 - as above, but includes Luna Park terminus.1 - Has "Ron, FYI" in ink on the top left hand corner.trams, tramways, w class, braking, instructions, malvern depot, university, burke rd, glen iris, kew, luna park, camberwell

An iron brake mechanism possibly from a farm implement. It has been painted red.It was probably used to control height on braking when attached to an agricultural implement. farm-implement agriculture

Brown cover book: contains details instruction of The Westinghouse Automatic Brake (64 pages). The context cover pictures demonstrations of the brake parts and operation procedures in very details.books, technical, railways, book, books, trains, railways, engines, locomotives, badham collection, collection, collections

Report - four pages - stapled in top left hand corner, titled "PCC - by F R Thompson", describing the control systems in a PCC tramcar, eg No. 980. Refers to drawings that are not included. Describes the control circuits, car drive, equipment, electric brakes, emergency dynamic braking, and service braking.trams, tramways, tramcars, controllers, electrical engineering, electrical equipment, motors, electric traction, pcc

Significant in being a detailed set of instructions for parking trams, hand overs, relief, responsibility for the security of the tram, including leaving the tram unattended. Regrettable incidents have happened. Issued 1965. Follows on from Reg item 261 an earlier version, but with less detailed instructions and no explanation.Two foolscap duplicated sheets titled "Special Order to Motormen (49/1)" giving instructions regarding 1) Responsibility (for trams), 2) Relief on the road, 3) Controller key, 4) Air brake handle, 5) leaving tram unattended with definition, general precautions, special precautions - such as parking the tram at Lydiard St North, parking trams at City Loop and 6) an explanation on the braking system at either end of the tram. Dated 25 January 1961. Printed from wax stencil and stapled along the top edge. Signed by F. K. White Manager. See Reg Item 261 for 9-1961 issue and 5371 for an undated issue.trams, tramways, ballarat, trams, secv, instructions, operations, lydiard st nth, city loop, braking